1984 CHEVROLET Recalls
Item Affected: ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
Date Announced: 10/15/1985
Description of Recall: THE FAN BLADE, WHEN SUBJECTED TO HIGH STRESS LEVELS, CAN FATIGUE AND BREAK APART AT THE HUB WHILE THE ENGINE IS RUNNING. CONSEQUENCE OF DEFECT: IF BREAKAGE OCCURS WHILE HOOD IS OPEN, A PERSON WORKING UNDER THE HOOD OR NEAR THE TRUCK COULD BE STRUCK BY A BLADE PART AND BE INJURED.
Conequence:
Action Need To Fix It: REPLACE ENGINE FAN.
Notes: SYSTEM:ENGINE FAN BLADE. VEHICLE DESCRIPTION: MEDUIM TRUCKS WITH A 6.2L DIESEL ENGINE, 4 SPEED MANUAL TRANSMISSION AND A 4.56 REAR AXLE RATIO.
Item Affected: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP
Date Announced: 10/16/1984
Description of Recall: DUE TO A MANUFACTURING PROBLEM WITH THE FUEL TANK FILLER PIPE, THE FUEL CAP MAY IMPROPERLY SEAL THE END OF THE FILLER PIPE. THIS FAILS TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 301, "FUEL SYSTEM INTEGRITY." IN THE EVENT OF A COLLISION, AN IMPROPERLY SEALED FILLER PIPE COULD ALLOW FUEL SPILLAGE.
Conequence:
Action Need To Fix It: THE DEALER WILL INSPECT AND REPLACE FUEL CAPS ON ALL AFFECTED VEHICLES WITHOUT CHARGE.
Notes: VEHICLE DESCRIPTION: LIGHT TRUCKS.SYSTEM: FUEL SYSTEM; FUEL TANK FILLER PIPE MOUNTING.CONSEQUENCES OF DEFECT: LEAKING FUEL COULD RESULT IN A VEHICLE FIRE ANDPERSONAL INJURY TO PASSENGERS IN THE EVENT OF AN ACCIDENT.
Item Affected: SEATS
Date Announced: 08/25/1986
Description of Recall: THREE BOLTS WHICH ATTACH THE SILL THAT SUPPORTS THE BASE OF THE SEAT WERE OMITTED; THEREFORE VEHICLES DO NOT COMPLY WITH FMVSS 210 AND FMVSS 207. CONSEQUENCE OF DEFECT: IN THE EVENT OF A CRASH, THE FLOOR PLATE COULD BUCKLE ALONG THE INBOARD SIDE CAUSING THE SEAT PEDESTAL TO BE IMBALANCED, AND INCREASING THE LIKELIHOOD OF INJURY TO THE SEAT OCCUPANT.
Conequence:
Action Need To Fix It: INSTALL MISSING BOLTS.
Notes: SYSTEM: SEAT ATTACHING BOLTS/FMVSS 207 AND 210. VEHICLE DESCRIPTION: LIGHT DUTY TRUCKS EQUIPPED WITH UNION CITY KING STEEL BODIES AND DRIVER/PASSENGER BUCKET SEATS WITH A TILT PEDESTAL.
Item Affected: EQUIPMENT
Date Announced: 10/24/2007
Description of Recall: CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Conequence: THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Action Need To Fix It: HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes: CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Item Affected: EQUIPMENT:APPLIANCE:AIR CONDITIONER
Date Announced: 08/20/1984
Description of Recall: PLASTIC PLUG LOCATED ON TOP OF THE FRONT AIR CONDITIONER WAS NOT REMOVED DURING ASSEMBLY. THIS DEFECT DISRUPTS NORMAL OPERATION OF EVAPORATOR BLOWER HOUSING.
Conequence:
Action Need To Fix It: REAR A/C SYSTEM BLOWER WILL BE INSPECTED FOR DAMAGE SUCH AS MELTING OR BURNING. IF NO DAMAGE IS DETECTED, THE RESISTOR WILL BE REPLACED AND ANY REMAINING PIECES WILL BE REMOVED. IF DAMAGE IS DETECTED, THE RESISTOR AND THE A/C EVAPORATOR INLET CASE WILL BE REPLACED.
Notes: VEHICLE DESCRIPTION: TRUCKS (VANS) EQUIPPED WITH FRONT AIR CONDITIONERS.SYSTEM: VENTILATION; AIR CONDITIONER.CONSEQUENCES OF DEFECT: ENGINE FIRE COULD START WITHOUT WARNING AND CAUSE FIREDAMAGE TO VEHICLE AND INJURY TO PASSENGERS.
Item Affected: SEAT BELTS:FRONT:ANCHORAGE
Date Announced: 07/18/1990
Description of Recall:
Conequence: OCCUPANTS WOULD NOT BE ADEQUATELY PROTECTED IN EVENT OFAN ACCIDENT OR SUDDEN STOP.
Action Need To Fix It: INSTALL PROPER MOUNTING HARDWARE AND SEAT BELTS.
Notes: NOTE: THIS RECALL WAS INITIALIZED BY MARK III INDUSTRIES.SYSTEM: SEAT BELTS, SEAT BELT ANCHORS, AND SEAT MOUNTING. DOM: SEPT. 1978 TOSEPT. 1984.DESCRIPTION ON DEFECT: IMPROPER MOUNTING HARDWARE AND IMPROPER SAFETY RESTRAINTSYSTEMS MAY HAVE BEEN INSTALLED IN THESE VEHICLES.
Item Affected: SERVICE BRAKES, HYDRAULIC:POWER ASSIST:HYDRAULIC
Date Announced: 10/16/1984
Description of Recall: VEHICLES HAVE A PRIMARY AND A RESERVE BRAKING SYSTEM. IF THE PRIMARY BRAKE SYSTEM BOOSTER FAILS, UNDER SOME CIRCUMSTANCES THE RESERVE SYSTEM MAY ALSO MALFUNCTION AND BRAKING ABILITY WILL BE IMPAIRED.
Conequence:
Action Need To Fix It: DEALER WILL INSTALL A NEW RESERVE BRAKE CONTROL MODULE AT NO COST TO OWNER.
Notes: VEHICLE DESCRIPTION: SCHOOL BUSES AND FORWARD CONTROL CHASSIS TRUCKS EQUIPPEDWITH HYPOWER DUAL HYDRAULIC BRAKE SYSTEMS.SYSTEM: SERVICE BRAKES; HYDRAULIC BRAKE SYSTEM, RESERVE BRAKES SYSTEMELECTRONIC CONTROL MODULE.CONSEQUENCES OF DEFECT: A REDUCTION OF BRAKING ABILITY IN A SITUATION WHENMINIMUM STOPPING DISTANCE IS REQUIRED COULD RESULT IN AN ACCIDENT WITHOUT PRIORWARNING.
Item Affected: SERVICE BRAKES, AIR:DRUM:CHAMBER
Date Announced: 08/03/1987
Description of Recall: SEVERE BRAKE CHATTER MAY CAUSE THE BRAKE CHAMBER MOUNTING BRACKETS ON EITHER SIDE TO DEVELOP CRACKS IN THE WELD AREA WHERE THE S CAM SHAFT TUBE ATTACHES TO THE CHAMBER SUPPORT SECTION.
Conequence: BRACKETS CAN BREAK, RESULTING IN LOSS OF BRAKING ABILITYAT THAT FRONT WHEEL, AND POSSIBLY RESTRICTED STEERING, WHICH COULD LEAD TO AVEHICLE CRASH WITHOUT PRIOR WARNING.
Action Need To Fix It: AS NECESSARY, INSTALL NEW REINFORCED FRONT BRAKE CHAMBER MOUNTING BRACKETS AND INSTALL A FRONT BRAKE LIMITING VALVE ON VEHICLES WITHOUT ONE.
Notes: SYSTEM: BRAKESVEHICLE DESCRIPTION: SCHOOL BUSES EQUIPPED WITH 7,500 LB. FRONT AXLE AND MEDIUMDUTY TRUCKS EQUIPPED WITH A 7,000 LB. FRONT AXLE.
Item Affected: SERVICE BRAKES, HYDRAULIC:FLUID
Date Announced: 07/07/1986
Description of Recall: SEVERE BRAKE CHATTER MAY CAUSE THE BRAKE CHAMBER MOUNTING BRACKETS ON EITHER SIDE TO DEVELOP CRACKS IN THE WELD AREA WHERE THE S-CAM SHAFT TUBE ATTACHES TO THE CHAMBER SUPPORT SECTION. CONSEQUENCE OF DEFECT: BRACKETS CAN BREAK, RESULTING IN LOSS OF BRAKING ABILITY AT THE FRONT WHEEL, AND POSSIBLY RESTRICT STEERING, WHICH COULD LEAD TO A VEHICLE CRASH WITHOUT PRIOR WARNING.
Conequence:
Action Need To Fix It: AS NECESSARY, REPLACE FRONT BRAKE CHAMBER MOUNTING BRACKETS AND INSTALL A FRONT BRAKE LIMITING VALVE.
Notes: SYSTEM: BRAKES. VEHICLE DESCRIPTION: SCHOOL BUSES EQUIPPED WITH A 7500 LB. FRONT AXLE AND WITHOUT A FRONT BRAKE LIMITING VALVE.
Item Affected: STEERING:LINKAGES:TIE ROD ASSEMBLY
Date Announced: 03/20/1984
Description of Recall: THE FRONT STEERING ALIGNMENT MAY NOT HAVE BEEN COMPLETED. THE TIE RODS, A PART OF THE STEERING LINKAGE WHICH TRANSMITS STEERING MOVEMENTS TO THE WHEELS, MAY NOT HAVE BEEN FASTENED COMPLETELY. THE ALIGNMENT OF THE STEERING WILL AFFECT THE VEHICLE"S HANDLING PROPERTIES. INCOMPLETE FASTENING OF THE STEERING TIE ROD MAY LEAD TO COMPLETE SEPARATION OF THE LINKAGE.
Conequence:
Action Need To Fix It: TIE ROD CLAMP FASTENERS WILL BE INSPECTED. IF NECESSARY, THE TOE-IN WILL BE SET, AND THE TIE ROD CLAMP FASTENERS WILL BE TIGHTENED. THERE WILL BE NO CHARGE FOR THESE SERVICES.
Notes: VEHICLE DESCRIPTION: LIGHT TRUCKS.SYSTEM: STEERING; TIE ROD CLAMP FASTENERS.CONSEQUENCES OF DEFECT: SEPARATION OF THE STEERING LINKAGE AND RESULTING LOSSOF STEERING CONTROL WITHOUT WARNING MAY LEAD TO AN ACCIDENT.
Item Affected: STEERING:LINKAGES:ARM:IDLER AND ATTACHMENT
Date Announced: 06/23/1986
Description of Recall: STEERING CONTROL ARM CAN BE OVERSTRESSED WITH HEAVY STEERING INPUT CAUSING IT TO CRACK AND IT COULD EVENTUALLY BREAK COMPLETELY. CONSEQUENCE OF DEFECT: IF THE STEERING CONTROL ARM BREAKS, COMPLETE LOSS OF STEERING ABILITY AND TRUCK CONTROL WOULD OCCUR WITHOUT WARNING WHICH COULD RESULT IN AN ACCIDENT.
Conequence:
Action Need To Fix It: INSTALL NEW STEERING ARM AND OTHER STEERING SYSTEM HARDWARE WHICH WILL PREVENT OVERSTRESSING INPUT CONDITIONS FROM OCCURRING.
Notes: SYSTEM: STEERING CONTROL ARM. VEHICLE DESCRIPTION: MEDIUM DUTY CONVENTIONAL TRUCKS EQUIPPED WITH 9,000 OR 12,000 LB. FRONT DRIVING STEERING AXLE AND AN 8.2 LITER ENGINE.
Item Affected: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
Date Announced: 01/20/1987
Description of Recall: TRUCKS FAILED TO COMPLY WITH REQUIREMENTS OF FMVSS 301, FUEL SYSTEM INTEGRITY, DURING A 30 MPH FRONTAL BARRIER TEST.
Conequence: GREATER THAN ACCEPTABLE FUEL SPILLAGE DURING AND AFTER ACOLLISION COULD RESULT IN A FIRE.
Action Need To Fix It: INSTALL AN ADDITIONAL SHIELD TO THE FRONT OF THE ORIGINAL SHIELD TO PROTECT THE FUEL TANK.
Notes: SYSTEM: FUEL TANK/FMVSS 301.VEHICLE DESCRIPTION: LIGHT DUTY CAB AND CHASSIS MODELS EQUIPPED WITH A LOWSERVICE BODY.
Item Affected: EQUIPMENT
Date Announced: 10/24/2007
Description of Recall: CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Conequence: THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Action Need To Fix It: HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes: CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Item Affected: WHEELS:CENTER SECTION
Date Announced: 10/26/1984
Description of Recall: IN SOME 16 X 6 DISC WHEELS A MANUFACTURING DEFECT MAY CAUSE THE WHEELS TO CRACK IN THE DROP CENTER PORTION OF THE RIM. IF THE CRACK WERE TO OCCUR ON A WHEEL WITH A TUBE TYPE TIRE MOUNTED TO IT, AND CONTINUED TO GO UNDETECTED, THE WHEEL COULD SPLIT, RESULTING IN A RAPID LOSS OF AIR FROM THE TIRE.
Conequence:
Action Need To Fix It: THE DEALER WILL INSPECT EACH WHEEL AND REPLACE IT IF NECESSARY, WITHOUT CHARGE.
Notes: VEHICLE DESCRIPTION: LIGHT TRUCKS EQUIPPED WITH DUAL REAR WHEELS.SYSTEM: SUSPENSION; WHEELS (16 X 6 DISC WHEELS).CONSEQUENCES OF DEFECT: RAPID AIR PRESSURE LOSS DURING VEHICLE OPERATION MAYCAUSE LOSS OF VEHICLE CONTROL WITHOUT PRIOR WARNING AND AN ACCIDENT MAY RESULT.
Item Affected: SEATS
Date Announced: 08/25/1986
Description of Recall: THREE BOLTS WHICH ATTACH THE SILL THAT SUPPORTS THE BASE OF THE SEAT WERE OMITTED; THEREFORE VEHICLES DO NOT COMPLY WITH FMVSS 210 AND FMVSS 207. CONSEQUENCE OF DEFECT: IN THE EVENT OF A CRASH, THE FLOOR PLATE COULD BUCKLE ALONG THE INBOARD SIDE CAUSING THE SEAT PEDESTAL TO BE IMBALANCED, AND INCREASING THE LIKELIHOOD OF INJURY TO THE SEAT OCCUPANT.
Conequence:
Action Need To Fix It: INSTALL MISSING BOLTS.
Notes: SYSTEM: SEAT ATTACHING BOLTS/FMVSS 207 AND 210. VEHICLE DESCRIPTION: LIGHT DUTY TRUCKS EQUIPPED WITH UNION CITY KING STEEL BODIES AND DRIVER/PASSENGER BUCKET SEATS WITH A TILT PEDESTAL.
Item Affected: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP
Date Announced: 10/16/1984
Description of Recall: DUE TO A MANUFACTURING PROBLEM WITH THE FUEL TANK FILLER PIPE, THE FUEL CAP MAY IMPROPERLY SEAL THE END OF THE FILLER PIPE. THIS FAILS TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 301, "FUEL SYSTEM INTEGRITY." IN THE EVENT OF A COLLISION, AN IMPROPERLY SEALED FILLER PIPE COULD ALLOW FUEL SPILLAGE.
Conequence:
Action Need To Fix It: THE DEALER WILL INSPECT AND REPLACE FUEL CAPS ON ALL AFFECTED VEHICLES WITHOUT CHARGE.
Notes: VEHICLE DESCRIPTION: LIGHT TRUCKS.SYSTEM: FUEL SYSTEM; FUEL TANK FILLER PIPE MOUNTING.CONSEQUENCES OF DEFECT: LEAKING FUEL COULD RESULT IN A VEHICLE FIRE ANDPERSONAL INJURY TO PASSENGERS IN THE EVENT OF AN ACCIDENT.
Item Affected: SEATS
Date Announced: 08/25/1986
Description of Recall: THREE BOLTS WHICH ATTACH THE SILL THAT SUPPORTS THE BASE OF THE SEAT WERE OMITTED; THEREFORE VEHICLES DO NOT COMPLY WITH FMVSS 210 AND FMVSS 207. CONSEQUENCE OF DEFECT: IN THE EVENT OF A CRASH, THE FLOOR PLATE COULD BUCKLE ALONG THE INBOARD SIDE CAUSING THE SEAT PEDESTAL TO BE IMBALANCED, AND INCREASING THE LIKELIHOOD OF INJURY TO THE SEAT OCCUPANT.
Conequence:
Action Need To Fix It: INSTALL MISSING BOLTS.
Notes: SYSTEM: SEAT ATTACHING BOLTS/FMVSS 207 AND 210. VEHICLE DESCRIPTION: LIGHT DUTY TRUCKS EQUIPPED WITH UNION CITY KING STEEL BODIES AND DRIVER/PASSENGER BUCKET SEATS WITH A TILT PEDESTAL.
Item Affected: ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
Date Announced: 10/15/1985
Description of Recall: THE FAN BLADE, WHEN SUBJECTED TO HIGH STRESS LEVELS, CAN FATIGUE AND BREAK APART AT THE HUB WHILE THE ENGINE IS RUNNING. CONSEQUENCE OF DEFECT: IF BREAKAGE OCCURS WHILE HOOD IS OPEN, A PERSON WORKING UNDER THE HOOD OR NEAR THE TRUCK COULD BE STRUCK BY A BLADE PART AND BE INJURED.
Conequence:
Action Need To Fix It: REPLACE ENGINE FAN.
Notes: SYSTEM:ENGINE FAN BLADE. VEHICLE DESCRIPTION: MEDUIM TRUCKS WITH A 6.2L DIESEL ENGINE, 4 SPEED MANUAL TRANSMISSION AND A 4.56 REAR AXLE RATIO.
Item Affected: EQUIPMENT
Date Announced: 10/24/2007
Description of Recall: CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Conequence: THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Action Need To Fix It: HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes: CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Item Affected: SEATS:FRONT ASSEMBLY:RECLINER
Date Announced: 02/06/1984
Description of Recall: SOME VEHICLES HAVE BUCKET SEAT BACK LOCKS THAT DO NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD 207, ANCHORAGE OF SEATS. IN EVENT OF A CRASH, THE SEAT BACK LOCK MAY NOT FUNCTION.
Conequence:
Action Need To Fix It: INSPECTION OF SEAT BACK LOCKS WILL BE PERFORMED. LOCKS THAT HAVE BENT, BROKEN OR MISSING HOOKS WILL BE REPLACED.
Notes: VEHICLE DESCRIPTION: TWO DOOR PASSENGER VEHICLES AND LIGHT TRUCKS EQUIPPED WITHAR9 OR AV5 BUCKET SEATS.SYSTEM: INTERIOR SYSTEMS, SEAT BACK LOCKS.CONSEQUENCES OF DEFECT: THE SEAT MAY FOLD FORWARD IN A CRASH, AND WOULDINCREASE THE LIKELIHOOD OF INJURY TO THE SEAT OCCUPANT.
Item Affected: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
Date Announced: 10/13/1983
Description of Recall: THE RIGHT FRONT CROSSOVER PIPE, WHICH CARRIES BRAKE HYDRAULIC FLUID, MAY BREAK AND LEAK FLUID. THIS OCCURS WHEN THE RIGHT FRONT FENDER SKIRT CONTACTS THE PIPE AND VIBRATION CAUSES THE PIPE TO WEAR THROUGH.
Conequence:
Action Need To Fix It: IF THE POSITION AND CLEARANCE OF THE BRAKE PIPE ARE INCORRECT, THE FENDER SKIRT WILL BE ADJUSTED AND A REPLACEMENT PIPE WILL BE INSTALLED.
Notes: VEHICLE DESCRIPTION: LIGHT TRUCKS, FOUR WHEEL DRIVE.SYSTEM: SERVICE BRAKES; FRONT BRAKE HYDRAULIC CROSSOVER PIPE.CONSEQUENCES OF DEFECT: FLUID LEAKAGE WILL RESULT IN THE LOSS OF FRONT BRAKING,AND AN INCREASE IN STOPPING DISTANCE. AN ACCIDENT MAY RESULT, PARTICULARLY INSITUATIONS REQUIRING MINIMUM STOPPING DISTANCE.NOTE: AN INCREASE IN BRAKE PEDAL TRAVEL AND ILLUMINATION OF THE BRAKE WARNINGLIGHT MAY INDICATE THE PROBLEM EXISTS.
Item Affected: EXTERIOR LIGHTING
Date Announced: 03/23/2006
Description of Recall: CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Conequence: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Action Need To Fix It: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes: THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES. FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS." CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Item Affected: STEERING:LINKAGES:ARM:IDLER AND ATTACHMENT
Date Announced: 06/23/1986
Description of Recall: STEERING CONTROL ARM CAN BE OVERSTRESSED WITH HEAVY STEERING INPUT CAUSING IT TO CRACK AND IT COULD EVENTUALLY BREAK COMPLETELY. CONSEQUENCE OF DEFECT: IF THE STEERING CONTROL ARM BREAKS, COMPLETE LOSS OF STEERING ABILITY AND TRUCK CONTROL WOULD OCCUR WITHOUT WARNING WHICH COULD RESULT IN AN ACCIDENT.
Conequence:
Action Need To Fix It: INSTALL NEW STEERING ARM AND OTHER STEERING SYSTEM HARDWARE WHICH WILL PREVENT OVERSTRESSING INPUT CONDITIONS FROM OCCURRING.
Notes: SYSTEM: STEERING CONTROL ARM. VEHICLE DESCRIPTION: MEDIUM DUTY CONVENTIONAL TRUCKS EQUIPPED WITH 9,000 OR 12,000 LB. FRONT DRIVING STEERING AXLE AND AN 8.2 LITER ENGINE.
Item Affected: EXTERIOR LIGHTING
Date Announced: 05/24/2006
Description of Recall: CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Conequence: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Action Need To Fix It: CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS. FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS." CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Item Affected: EXTERIOR LIGHTING:HEADLIGHTS
Date Announced: 08/11/2008
Description of Recall: K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Conequence: WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Action Need To Fix It: K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY HONDA, FORD, OR CHRYSLER LLC. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Item Affected: SEATS:FRONT ASSEMBLY:RECLINER
Date Announced: 02/06/1984
Description of Recall: SOME VEHICLES HAVE BUCKET SEAT BACK LOCKS THAT DO NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD 207, ANCHORAGE OF SEATS. IN EVENT OF A CRASH, THE SEAT BACK LOCK MAY NOT FUNCTION.
Conequence:
Action Need To Fix It: INSPECTION OF SEAT BACK LOCKS WILL BE PERFORMED. LOCKS THAT HAVE BENT, BROKEN OR MISSING HOOKS WILL BE REPLACED.
Notes: VEHICLE DESCRIPTION: TWO DOOR PASSENGER VEHICLES AND LIGHT TRUCKS EQUIPPED WITHAR9 OR AV5 BUCKET SEATS.SYSTEM: INTERIOR SYSTEMS, SEAT BACK LOCKS.CONSEQUENCES OF DEFECT: THE SEAT MAY FOLD FORWARD IN A CRASH, AND WOULDINCREASE THE LIKELIHOOD OF INJURY TO THE SEAT OCCUPANT.
Item Affected: SUSPENSION:REAR:SPRINGS:AIR SUSPENSION SYSTEM:LINES AND FITTINGS
Date Announced: 05/18/1984
Description of Recall: REAR AXLE BRAKE TEE JUNCTION BLOCK WHICH JOINS THE BRAKE LINES IN THE REAR OF THE VEHICLE, WAS PAINTED BY MISTAKE. THE PAINT COULD CAUSE LOOSENING OF THE BRAKE HOSE CONNECTION WHICH MAY RESULT IN A BRAKE FLUID LEAK AND LOSS OF REAR BRAKES.
Conequence:
Action Need To Fix It: DEALER WILL REMOVE PAINT IF NECESSARY AND THEN CHECK TO ENSURE PROPER FUNCTION OF BRAKES.
Notes: VEHICLE DESCRIPTION: MEDIUM TRUCKS.SYSTEM: SERVICE BRAKES; REAR AXLE JUNCTION BLOCK.CONSEQUENCES OF DEFECT: BRAKES WILL CONTINUE TO FUNCTION BUT STOPPING DISTANCEWILL BE INCREASED. IN CIRCUMSTANCES WHERE MINIMUM STOPPING DISTANCE ISREQUIRED, AN ACCIDENT COULD RESULT.
Item Affected: EQUIPMENT
Date Announced: 10/24/2007
Description of Recall: CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Conequence: THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Action Need To Fix It: HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes: CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Item Affected: VEHICLE SPEED CONTROL
Date Announced: 06/16/1989
Description of Recall: A SMALL NYLON BUSHING IN THE CRUISE CONTROL SERVO BAIL MAY SLIP OUT OF PLACE, CAUSING INTERMITTENT AND UNEXPECTED INCREASES IN ENGINE SPEED OR DIESELING (ENGINE RUN ON WITH IGNITION OFF).
Conequence: SERVO ROD ASSEMBLY COULD CATCH ON ENGINE COMPONENTS ANDRESULT IN A STUCK THROTTLE WITH POTENTIAL FOR A VEHICLE CRASH.
Action Need To Fix It: INSTALL A NEW BUSHING IN CRUISE CONTROL SERVO BAIL.
Notes: SYSTEM: CRUISE CONTROL.VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH CRUISE CONTROL ANDCERTAIN GASOLINE AND DIESEL ENGINES.
Item Affected: FUEL SYSTEM, GASOLINE
Date Announced: 05/19/2006
Description of Recall: CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Conequence: THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Action Need To Fix It: HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Item Affected: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
Date Announced: 03/29/1985
Description of Recall: THE FUEL SYSTEM MAY LEAK AT THE THROTTLE BODY INJECTION FUEL FEED PIPE CONNECTION. CONSEQUENCE OF DEFECT: THIS LEAKAGE COULD RESULT IN AN UNDERHOOD FIRE WHICH COULD SPREAD TO THE PASSENGER COMPARTMENT AND CAUSE BURN INJURIES TO OCCUPANTS.
Conequence:
Action Need To Fix It: REPLACE THE FUEL FEED PIPE.
Notes: VEHICLE DESCRIPTION: PASSENGER CARS EQUIPPED WITH 2.5L L4 ENGINES.SYSTEM: FUEL.
Item Affected: SERVICE BRAKES, AIR:SUPPLY:HOSES, LINES/PIPING, AND FITTINGS
Date Announced: 07/02/1985
Description of Recall: THE FRONT AIR BRAKE HOSE MAY CONTACT THE INNER FENDER ON THE LEFT AND/OR RIGHT SIDES OF SOME TRUCKS. IN SOME INSTANCES, THE BRAKE HOSE MAY RUB THROUGH, RESULTING IN A LOSS OF AIR PRESSURE UPON BRAKE APPLICATION. CONSEQUENCE OF DEFECT: BRAKE HOSE MAY RUB THROUGH CAUSING AIR PRESSURE LOSS WHEN BRAKES ARE APPLIED AND REDUCED BRAKING ABILITY. A REDUCTION OF BRAKING ABILITY AT A TIME WHEN MINIMUM STOPPING DISTANCE IS REQUIRED COULD RESULT IN A VEHICLE CRASH WITHOUT PRIOR WARNING.
Conequence:
Action Need To Fix It: INSTALL NEW BRAKE CHAMBER SUPPORT BRACKETS, BRAKE LINE ELBOWS, AND AIR BRAKE HOSES, AS NECESSARY.
Notes: VEHICLE DESCRIPTION: MEDIUM DUTY TRUCKS EQUIPPED WITH TILT HOODS, 7000# FRONT AXLE AND AIR BRAKES. SYSTEM: FRONT BRAKE HOSE.
Item Affected: EQUIPMENT
Date Announced: 10/24/2007
Description of Recall: CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Conequence: THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Action Need To Fix It: HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes: CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Item Affected: POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/LINKAGE
Date Announced: 04/23/1984
Description of Recall: THE VEHICLES WERE ASSEMBLED WITHOUT THE RETAINING CLIP WHICH IS NEEDED TO KEEP THE CLUTCH CABLE FROM CONTACTING THE MASTER CYLINDER BRAKE PIPE. OVER AN EXTENDED TIME, THE CLUTCH CABLE COULD RUB THROUGH THE MASTER CYLINDER BRAKE PIPE, RESULTING IN A BRAKE FLUID LEAK AND LOSS OF FRONT BRAKES.
Conequence:
Action Need To Fix It: THE MISSING CLUTCH CABLE CLIP WILL BE INSTALLED AND THE BRAKE PIPE WILL BE REPLACED, IF NECESSARY, AT NO COST TO THE OWNER.
Notes: VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH MANUAL TRANSMISSIONS.SYSTEM: POWER TRAIN; CLUTCH CABLE CLIP.CONSEQUENCES OF DEFECT: THE REMAINING PORTION OF THE DUAL BRAKING SYSTEM WILLENABLE THE VEHICLE TO STOP, BUT THE STOPPING DISTANCE WILL BE INCREASED WITHOUTPRIOR WARNING. THIS COULD RESULT IN AN ACCIDENT.
Item Affected: EQUIPMENT:AIR CONDITIONER
Date Announced: 08/20/1984
Description of Recall: PLASTIC PLUG LOCATED ON TOP OF THE FRONT AIR CONDITIONER WAS NOT REMOVED DURING ASSEMBLY. THIS DEFECT DISRUPTS NORMAL OPERATION OF EVAPORATOR BLOWER HOUSING.
Conequence:
Action Need To Fix It: REAR A/C SYSTEM BLOWER WILL BE INSPECTED FOR DAMAGE SUCH AS MELTING OR BURNING. IF NO DAMAGE IS DETECTED, THE RESISTOR WILL BE REPLACED AND ANY REMAINING PIECES WILL BE REMOVED. IF DAMAGE IS DETECTED, THE RESISTOR AND THE A/C EVAPORATOR INLET CASE WILL BE REPLACED.
Notes: VEHICLE DESCRIPTION: TRUCKS (VANS) EQUIPPED WITH FRONT AIR CONDITIONERS.SYSTEM: VENTILATION; AIR CONDITIONER.CONSEQUENCES OF DEFECT: ENGINE FIRE COULD START WITHOUT WARNING AND CAUSE FIREDAMAGE TO VEHICLE AND INJURY TO PASSENGERS.
Item Affected: EQUIPMENT
Date Announced: 10/24/2007
Description of Recall: CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Conequence: THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Action Need To Fix It: HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes: CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Item Affected: EQUIPMENT:APPLIANCE:AIR CONDITIONER
Date Announced: 08/20/1984
Description of Recall: PLASTIC PLUG LOCATED ON TOP OF THE FRONT AIR CONDITIONER WAS NOT REMOVED DURING ASSEMBLY. THIS DEFECT DISRUPTS NORMAL OPERATION OF EVAPORATOR BLOWER HOUSING.
Conequence:
Action Need To Fix It: REAR A/C SYSTEM BLOWER WILL BE INSPECTED FOR DAMAGE SUCH AS MELTING OR BURNING. IF NO DAMAGE IS DETECTED, THE RESISTOR WILL BE REPLACED AND ANY REMAINING PIECES WILL BE REMOVED. IF DAMAGE IS DETECTED, THE RESISTOR AND THE A/C EVAPORATOR INLET CASE WILL BE REPLACED.
Notes: VEHICLE DESCRIPTION: TRUCKS (VANS) EQUIPPED WITH FRONT AIR CONDITIONERS.SYSTEM: VENTILATION; AIR CONDITIONER.CONSEQUENCES OF DEFECT: ENGINE FIRE COULD START WITHOUT WARNING AND CAUSE FIREDAMAGE TO VEHICLE AND INJURY TO PASSENGERS.
Item Affected: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP
Date Announced: 10/16/1984
Description of Recall: DUE TO A MANUFACTURING PROBLEM WITH THE FUEL TANK FILLER PIPE, THE FUEL CAP MAY IMPROPERLY SEAL THE END OF THE FILLER PIPE. THIS FAILS TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 301, "FUEL SYSTEM INTEGRITY." IN THE EVENT OF A COLLISION, AN IMPROPERLY SEALED FILLER PIPE COULD ALLOW FUEL SPILLAGE.
Conequence:
Action Need To Fix It: THE DEALER WILL INSPECT AND REPLACE FUEL CAPS ON ALL AFFECTED VEHICLES WITHOUT CHARGE.
Notes: VEHICLE DESCRIPTION: LIGHT TRUCKS.SYSTEM: FUEL SYSTEM; FUEL TANK FILLER PIPE MOUNTING.CONSEQUENCES OF DEFECT: LEAKING FUEL COULD RESULT IN A VEHICLE FIRE ANDPERSONAL INJURY TO PASSENGERS IN THE EVENT OF AN ACCIDENT.
Item Affected: EQUIPMENT
Date Announced: 10/24/2007
Description of Recall: CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Conequence: THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Action Need To Fix It: HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes: CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Item Affected: EQUIPMENT
Date Announced: 10/24/2007
Description of Recall: CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Conequence: THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Action Need To Fix It: HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes: CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Item Affected: EQUIPMENT
Date Announced: 10/24/2007
Description of Recall: CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Conequence: THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Action Need To Fix It: HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes: CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Item Affected: ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES
Date Announced: 08/25/1983
Description of Recall: THE INSULATION OF THE BATTERY CABLE, BECAUSE OF ITS POSITION, RUBS AGAINST SOME OF THE ENGINE WIRING COMPONENTS. ONCE THE INSULATION IS WORN THROUGH, THE BATTERY COULD RAPIDLY DISCHARGE.
Conequence:
Action Need To Fix It: DEALER WILL INSTALL A NEW ENGINE HARNESS RETAINER BRACKET, PROTECTIVE CONDUIT, CABLE CLIPS, A CABLE TIE STRAP AND WILL REPOSITION THE TERMINALS ON THE GROUND STUD ON ALL INVOLVED VEHICLES.
Notes: VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: ELECTRICAL; BATTERY CABLE INSULATION.CONSEQUENCES OF DEFECT: THE HEADLIGHTS WOULD CEASE TO FUNCTION, DUE TO LOSS OFBATTERY POWER; DRIVING AT NIGHT, IN FOG OR OTHER SEVERE WEATHER CONDITIONSCOULD RESULT IN AN ACCIDENT.
Item Affected: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER
Date Announced: 07/07/1983
Description of Recall: ATTACHING BOLTS WERE MISTAKENLY COATED WITH A SLIPPERY MATERIAL DURING PRODUCTION. THIS MATERIAL WILL ACT AS A LUBRICANT AND BOLTS MAY LOOSEN AND EVENTUALLY FALL OFF.
Conequence:
Action Need To Fix It: DEALER WILL INSTALL NEW CALIPER BRACKET BOLTS FREE OF CHARGE.
Notes: VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: SERVICE BRAKES; FRONT BRAKE CALIPER BRACKET TO STEERING KNUCKLEATTACHING BOLT.CONSEQUENCES OF DEFECT: THE FRONT BRAKE ASSEMBLY COULD BECOME PARTIALLYSEPARATED FROM THE KNUCKLE ASSEMBLY, CAUSING THE WHEEL TO LOCK. LOSS OF VEHICLECONTROL WITHOUT PRIOR WARNING AND AN ACCIDENT COULD RESULT.
Item Affected: VEHICLE SPEED CONTROL
Date Announced: 03/19/1985
Description of Recall: THE CRUISE CONTROL VACUUM SOLENOID VALVES MAY MALFUNCTION AT ANY TIME THE ENGINE IS RUNNING AND THE CRUISE CONTROL IS ENGAGED AND CAUSE UNEXPECTED ENGINE ACCELERATION. CONSEQUENCE OF DEFECT: LOSS OF ACCELERATOR CONTROL COULD RESULT IN A VEHICLE CRASH WITHOUT PRIOR WARNING.
Conequence:
Action Need To Fix It: INSTALL AND RELOCATE A NEW CRUISE CONTROL SERVO ASSEMBLY.
Notes: VEHICLE DESCRIPTION: PASSENGER CARS EQUIPPED WITH RPO K34 CRUISE CONTROL. SYSTEM: CRUISE CONTROL.
Item Affected: POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT
Date Announced: 10/01/1985
Description of Recall: CARS MAY LOSE THE WIRE SNAP RINGS THAT HOLD THE DIFFERENTIAL CROSS SHAFT IN POSITION IN THE REAR AXLE DIFFERENTIAL CASE ASSEMBLY, ALLOWING THE SHAFT TO MOVE. CONSEQUENCE OF DEFECT: THE CROSS SHAFT MOVEMENT COULD CAUSE THE SHAFT TO CONTACT THE CARRIER OR PINION TEETH, POSSIBLY LOCKING UP THE REAR WHEELS AND RESULT IN A CRASH WITHOUT PRIOR WARNING.
Conequence:
Action Need To Fix It: INSTALL A REAR AXLE DIFFERENTIAL CROSS SHAFT RETAINING KIT.
Notes: SYSTEM: REAR AXLE. VEHICLE DESCRIPTION: PASSENGER CARS WITH 3.07 AXLE AND F41 SUSPENSION.
Item Affected: SEAT BELTS:FRONT:ANCHORAGE
Date Announced: 09/04/1991
Description of Recall: UNDER CERTAIN VEHICLE OPERATIONS AND OCCUPANT USAGE CONDITIONS, THE SAFETY BELTS CAN LOCKUP OR JAM IN THE SAFETY BELT RETRACTOR.
Conequence: IF LOCKUP OCCURS, IT IS IMPOSSIBLE TO PULL BELT OUT OFTHE RETRACTOR. THE OCCUPANT OF A SEAT WITH AN UNUSABLE SAFETY BELT ISSUBJECT TO INCREASED RISK OF INJURY OR DEATH IN THE EVENT OF A SUDDEN STOP ORACCIDENT.
Action Need To Fix It: REPLACE THE SAFETY BELTS IF THE LOCKUP OCCURS.
Notes: SYSTEM: SAFETY BELTS.VEHICLE DESCRIPTION: PASSENGER CARS.
Item Affected: PARKING BRAKE:DRIVELINE:AIR:CHAMBER
Date Announced: 10/07/1985
Description of Recall: THE REAR BRAKE RELEASE TIME MAY BE GREATER THAN THE TIME SPECIFIED IN FMVSS 121, "AIR BRAKE SYSTEM". IN ADDITION, SOME TRACTORS MAY HAVE WARPED PARKING BRAKE APPLY SPRINGS WHICH ALSO EFFECT THE REAR BRAKE RELEASE TIME. CONSEQUENCE OF DEFECT: TRACTORS FAIL TO MEET THE STOPPING DISTANCE SPECIFIED IN FMVSS 121 WHICH IS REQUIRED TO STOP THE TRUCK SAFELY.
Conequence:
Action Need To Fix It: INSTALL A QUICK RELEASE VALVE IN THE TRAILER SERVICE AIR LINE AND INCREASE THE DIAMETER OF THE REAR SERVICE BRAKE LINE. ALSO INSPECT REAR SPRING BRAKE CHAMBER AND RELEASE IF NECESSARY.
Notes: SYSTEM: AIR BRAKES. VEHICLE DESCRIPTION: TRACTORS EQUIPPED WITH RPO RQ3 TRACTOR APPLICATION.
Item Affected: FUEL SYSTEM, GASOLINE
Date Announced: 05/19/2006
Description of Recall: CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Conequence: THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Action Need To Fix It: HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Item Affected: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
Date Announced: 03/29/1985
Description of Recall: THE FUEL SYSTEM MAY LEAK AT THE THROTTLE BODY INJECTION FUEL FEED PIPE CONNECTION. CONSEQUENCE OF DEFECT: THIS LEAKAGE COULD RESULT IN AN UNDERHOOD FIRE WHICH COULD SPREAD TO THE PASSENGER COMPARTMENT AND CAUSE BURN INJURIES TO OCCUPANTS.
Conequence:
Action Need To Fix It: REPLACE THE FUEL FEED PIPE.
Notes: VEHICLE DESCRIPTION: PASSENGER CARS EQUIPPED WITH 2.5L L4 ENGINES.SYSTEM: FUEL.
Item Affected: POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE)
Date Announced: 04/23/1984
Description of Recall: THE VEHICLES WERE ASSEMBLED WITHOUT THE RETAINING CLIP WHICH IS NEEDED TO KEEP THE CLUTCH CABLE FROM CONTACTING THE MASTER CYLINDER BRAKE PIPE. OVER AN EXTENDED TIME, THE CLUTCH CABLE COULD RUB THROUGH THE MASTER CYLINDER BRAKE PIPE, RESULTING IN A BRAKE FLUID LEAK AND LOSS OF FRONT BRAKES.
Conequence:
Action Need To Fix It: THE MISSING CLUTCH CABLE CLIP WILL BE INSTALLED AND THE BRAKE PIPE WILL BE REPLACED, IF NECESSARY, AT NO COST TO THE OWNER.
Notes: VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH MANUAL TRANSMISSIONS.SYSTEM: POWER TRAIN; CLUTCH CABLE CLIP.CONSEQUENCES OF DEFECT: THE REMAINING PORTION OF THE DUAL BRAKING SYSTEM WILLENABLE THE VEHICLE TO STOP, BUT THE STOPPING DISTANCE WILL BE INCREASED WITHOUTPRIOR WARNING. THIS COULD RESULT IN AN ACCIDENT.
Item Affected: SEATS:FRONT ASSEMBLY:RECLINER
Date Announced: 02/06/1984
Description of Recall: SOME VEHICLES HAVE BUCKET SEAT BACK LOCKS THAT DO NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD 207, ANCHORAGE OF SEATS. IN EVENT OF A CRASH, THE SEAT BACK LOCK MAY NOT FUNCTION.
Conequence:
Action Need To Fix It: INSPECTION OF SEAT BACK LOCKS WILL BE PERFORMED. LOCKS THAT HAVE BENT, BROKEN OR MISSING HOOKS WILL BE REPLACED.
Notes: VEHICLE DESCRIPTION: TWO DOOR PASSENGER VEHICLES AND LIGHT TRUCKS EQUIPPED WITHAR9 OR AV5 BUCKET SEATS.SYSTEM: INTERIOR SYSTEMS, SEAT BACK LOCKS.CONSEQUENCES OF DEFECT: THE SEAT MAY FOLD FORWARD IN A CRASH, AND WOULDINCREASE THE LIKELIHOOD OF INJURY TO THE SEAT OCCUPANT.
Item Affected: EQUIPMENT
Date Announced: 10/24/2007
Description of Recall: CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Conequence: THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Action Need To Fix It: HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes: CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Item Affected: EQUIPMENT:APPLIANCE:AIR CONDITIONER
Date Announced: 08/20/1984
Description of Recall: PLASTIC PLUG LOCATED ON TOP OF THE FRONT AIR CONDITIONER WAS NOT REMOVED DURING ASSEMBLY. THIS DEFECT DISRUPTS NORMAL OPERATION OF EVAPORATOR BLOWER HOUSING.
Conequence:
Action Need To Fix It: REAR A/C SYSTEM BLOWER WILL BE INSPECTED FOR DAMAGE SUCH AS MELTING OR BURNING. IF NO DAMAGE IS DETECTED, THE RESISTOR WILL BE REPLACED AND ANY REMAINING PIECES WILL BE REMOVED. IF DAMAGE IS DETECTED, THE RESISTOR AND THE A/C EVAPORATOR INLET CASE WILL BE REPLACED.
Notes: VEHICLE DESCRIPTION: TRUCKS (VANS) EQUIPPED WITH FRONT AIR CONDITIONERS.SYSTEM: VENTILATION; AIR CONDITIONER.CONSEQUENCES OF DEFECT: ENGINE FIRE COULD START WITHOUT WARNING AND CAUSE FIREDAMAGE TO VEHICLE AND INJURY TO PASSENGERS.
Item Affected: EXTERIOR LIGHTING
Date Announced: 03/23/2006
Description of Recall: CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Conequence: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Action Need To Fix It: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes: THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES. FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS." CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Item Affected: EQUIPMENT
Date Announced: 10/24/2007
Description of Recall: CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Conequence: THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Action Need To Fix It: HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes: CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Item Affected: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
Date Announced: 10/13/1983
Description of Recall: THE RIGHT FRONT CROSSOVER PIPE, WHICH CARRIES BRAKE HYDRAULIC FLUID, MAY BREAK AND LEAK FLUID. THIS OCCURS WHEN THE RIGHT FRONT FENDER SKIRT CONTACTS THE PIPE AND VIBRATION CAUSES THE PIPE TO WEAR THROUGH.
Conequence:
Action Need To Fix It: IF THE POSITION AND CLEARANCE OF THE BRAKE PIPE ARE INCORRECT, THE FENDER SKIRT WILL BE ADJUSTED AND A REPLACEMENT PIPE WILL BE INSTALLED.
Notes: VEHICLE DESCRIPTION: LIGHT TRUCKS, FOUR WHEEL DRIVE.SYSTEM: SERVICE BRAKES; FRONT BRAKE HYDRAULIC CROSSOVER PIPE.CONSEQUENCES OF DEFECT: FLUID LEAKAGE WILL RESULT IN THE LOSS OF FRONT BRAKING,AND AN INCREASE IN STOPPING DISTANCE. AN ACCIDENT MAY RESULT, PARTICULARLY INSITUATIONS REQUIRING MINIMUM STOPPING DISTANCE.NOTE: AN INCREASE IN BRAKE PEDAL TRAVEL AND ILLUMINATION OF THE BRAKE WARNINGLIGHT MAY INDICATE THE PROBLEM EXISTS.
Item Affected: POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
Date Announced: 04/04/1988
Description of Recall: THE AUTOMATIC TRANSMISSION SHIFT LEVER BUTTON MECHANISM MAY WEAR TO THE POINT THAT THE BUTTON ON THE SHIFT LEVER NO LONGER NEEDS TO BE DEPRESSED TO SHIFT GEARS.
Conequence: A LEVER WITH THIS CONDITION COULD BE INADVERTENTLY BUMPEDOR MOVED FROM DRIVE TO REVERSE BY THE DRIVER OR A PASSENGER WHILE THE VEHICLEIS BEING DRIVEN. A SUDDEN UNEXPECTED SHIFTING COULD CAUSE LOSS OF VEHICLECONTROL AND A VEHICLE CRASH.
Action Need To Fix It: A NEWLY DESIGNED TRANSMISSION SHIFT LEVER WILL BE INSTALLED ON ALL VEHICLES.
Notes: SYSTEM: TRANSMISSION/SHIFT LEVER.VEHICLE DESCRIPTION: PASSENGER CARS.
Item Affected: SEATS:FRONT ASSEMBLY:RECLINER
Date Announced: 02/06/1984
Description of Recall: SOME VEHICLES HAVE BUCKET SEAT BACK LOCKS THAT DO NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD 207, ANCHORAGE OF SEATS. IN EVENT OF A CRASH, THE SEAT BACK LOCK MAY NOT FUNCTION.
Conequence:
Action Need To Fix It: INSPECTION OF SEAT BACK LOCKS WILL BE PERFORMED. LOCKS THAT HAVE BENT, BROKEN OR MISSING HOOKS WILL BE REPLACED.
Notes: VEHICLE DESCRIPTION: TWO DOOR PASSENGER VEHICLES AND LIGHT TRUCKS EQUIPPED WITHAR9 OR AV5 BUCKET SEATS.SYSTEM: INTERIOR SYSTEMS, SEAT BACK LOCKS.CONSEQUENCES OF DEFECT: THE SEAT MAY FOLD FORWARD IN A CRASH, AND WOULDINCREASE THE LIKELIHOOD OF INJURY TO THE SEAT OCCUPANT.
Item Affected: FUEL SYSTEM, GASOLINE
Date Announced: 05/19/2006
Description of Recall: CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Conequence: THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Action Need To Fix It: HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Item Affected: SEATS:FRONT ASSEMBLY:RECLINER
Date Announced: 02/06/1984
Description of Recall: SOME VEHICLES HAVE BUCKET SEAT BACK LOCKS THAT DO NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD 207, ANCHORAGE OF SEATS. IN EVENT OF A CRASH, THE SEAT BACK LOCK MAY NOT FUNCTION.
Conequence:
Action Need To Fix It: INSPECTION OF SEAT BACK LOCKS WILL BE PERFORMED. LOCKS THAT HAVE BENT, BROKEN OR MISSING HOOKS WILL BE REPLACED.
Notes: VEHICLE DESCRIPTION: TWO DOOR PASSENGER VEHICLES AND LIGHT TRUCKS EQUIPPED WITHAR9 OR AV5 BUCKET SEATS.SYSTEM: INTERIOR SYSTEMS, SEAT BACK LOCKS.CONSEQUENCES OF DEFECT: THE SEAT MAY FOLD FORWARD IN A CRASH, AND WOULDINCREASE THE LIKELIHOOD OF INJURY TO THE SEAT OCCUPANT.
Item Affected: SEATS
Date Announced: 05/07/1987
Description of Recall: THE METAL FLOOR PAN ANCHOR BAR COULD FATIGUE AND BREAK AROUND THE LEFT FRONT OUTER SEAT ADJUSTER STUD OF THE DRIVERS SEAT, ALLOWING THE STUD TO SEPARATE FROM THE FLOOR PAN ANCHOR BAR.
Conequence: DRIVERS SEAT COULD TIP REARWARD UNEXPECTEDLY; THIS COULDRESULT IN LOSS OF CONTROL AND A VEHICLE CRASH WITHOUT PRIOR WARNING.
Action Need To Fix It: INSTALL A REINFORCEMENT BRACKET ON THE FLOOR PAN ANCHOR BAR AT THE LEFT FRONT OUTER SEAT ADJUSTER POSITION OF THE DRIVERS SEAT.
Notes: SYSTEM: DRIVERS SEAT.VEHICLE DESCRIPTION: PASSENGER CARS EQUIPPED WITH MANUALLY ADJUSTABLE DRIVERSSEAT.
Item Affected: ELECTRICAL SYSTEM:BATTERY:CABLES
Date Announced: 08/25/1983
Description of Recall: THE INSULATION OF THE BATTERY CABLE, BECAUSE OF ITS POSITION, RUBS AGAINST SOME OF THE ENGINE WIRING COMPONENTS. ONCE THE INSULATION IS WORN THROUGH, THE BATTERY COULD RAPIDLY DISCHARGE.
Conequence:
Action Need To Fix It: DEALER WILL INSTALL A NEW ENGINE HARNESS RETAINER BRACKET, PROTECTIVE CONDUIT, CABLE CLIPS, A CABLE TIE STRAP AND WILL REPOSITION THE TERMINALS ON THE GROUND STUD ON ALL INVOLVED VEHICLES.
Notes: VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: ELECTRICAL; BATTERY CABLE INSULATION.CONSEQUENCES OF DEFECT: THE HEADLIGHTS WOULD CEASE TO FUNCTION, DUE TO LOSS OFBATTERY POWER; DRIVING AT NIGHT, IN FOG OR OTHER SEVERE WEATHER CONDITIONSCOULD RESULT IN AN ACCIDENT.
Item Affected: EQUIPMENT
Date Announced: 10/24/2007
Description of Recall: CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Conequence: THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Action Need To Fix It: HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes: CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Item Affected: STEERING:LINKAGES:TIE ROD ASSEMBLY
Date Announced: 03/20/1984
Description of Recall: THE FRONT STEERING ALIGNMENT MAY NOT HAVE BEEN COMPLETED. THE TIE RODS, A PART OF THE STEERING LINKAGE WHICH TRANSMITS STEERING MOVEMENTS TO THE WHEELS, MAY NOT HAVE BEEN FASTENED COMPLETELY. THE ALIGNMENT OF THE STEERING WILL AFFECT THE VEHICLE"S HANDLING PROPERTIES. INCOMPLETE FASTENING OF THE STEERING TIE ROD MAY LEAD TO COMPLETE SEPARATION OF THE LINKAGE.
Conequence:
Action Need To Fix It: TIE ROD CLAMP FASTENERS WILL BE INSPECTED. IF NECESSARY, THE TOE-IN WILL BE SET, AND THE TIE ROD CLAMP FASTENERS WILL BE TIGHTENED. THERE WILL BE NO CHARGE FOR THESE SERVICES.
Notes: VEHICLE DESCRIPTION: LIGHT TRUCKS.SYSTEM: STEERING; TIE ROD CLAMP FASTENERS.CONSEQUENCES OF DEFECT: SEPARATION OF THE STEERING LINKAGE AND RESULTING LOSSOF STEERING CONTROL WITHOUT WARNING MAY LEAD TO AN ACCIDENT.
Item Affected: WHEELS:HUBCAP/COVER
Date Announced: 10/26/1984
Description of Recall: IN SOME 16 X 6 DISC WHEELS A MANUFACTURING DEFECT MAY CAUSE THE WHEELS TO CRACK IN THE DROP CENTER PORTION OF THE RIM. IF THE CRACK WERE TO OCCUR ON A WHEEL WITH A TUBE TYPE TIRE MOUNTED TO IT, AND CONTINUED TO GO UNDETECTED, THE WHEEL COULD SPLIT, RESULTING IN A RAPID LOSS OF AIR FROM THE TIRE.
Conequence:
Action Need To Fix It: THE DEALER WILL INSPECT EACH WHEEL AND REPLACE IT IF NECESSARY, WITHOUT CHARGE.
Notes: VEHICLE DESCRIPTION: LIGHT TRUCKS EQUIPPED WITH DUAL REAR WHEELS.SYSTEM: SUSPENSION; WHEELS (16 X 6 DISC WHEELS).CONSEQUENCES OF DEFECT: RAPID AIR PRESSURE LOSS DURING VEHICLE OPERATION MAYCAUSE LOSS OF VEHICLE CONTROL WITHOUT PRIOR WARNING AND AN ACCIDENT MAY RESULT.
Item Affected: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
Date Announced: 01/20/1987
Description of Recall: TRUCKS FAILED TO COMPLY WITH REQUIREMENTS OF FMVSS 301, FUEL SYSTEM INTEGRITY, DURING A 30 MPH FRONTAL BARRIER TEST.
Conequence: GREATER THAN ACCEPTABLE FUEL SPILLAGE DURING AND AFTER ACOLLISION COULD RESULT IN A FIRE.
Action Need To Fix It: INSTALL AN ADDITIONAL SHIELD TO THE FRONT OF THE ORIGINAL SHIELD TO PROTECT THE FUEL TANK.
Notes: SYSTEM: FUEL TANK/FMVSS 301.VEHICLE DESCRIPTION: LIGHT DUTY CAB AND CHASSIS MODELS EQUIPPED WITH A LOWSERVICE BODY.
Item Affected: SEATS:FRONT ASSEMBLY:RECLINER
Date Announced: 02/06/1984
Description of Recall: SOME VEHICLES HAVE BUCKET SEAT BACK LOCKS THAT DO NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD 207, ANCHORAGE OF SEATS. IN EVENT OF A CRASH, THE SEAT BACK LOCK MAY NOT FUNCTION.
Conequence:
Action Need To Fix It: INSPECTION OF SEAT BACK LOCKS WILL BE PERFORMED. LOCKS THAT HAVE BENT, BROKEN OR MISSING HOOKS WILL BE REPLACED.
Notes: VEHICLE DESCRIPTION: TWO DOOR PASSENGER VEHICLES AND LIGHT TRUCKS EQUIPPED WITHAR9 OR AV5 BUCKET SEATS.SYSTEM: INTERIOR SYSTEMS, SEAT BACK LOCKS.CONSEQUENCES OF DEFECT: THE SEAT MAY FOLD FORWARD IN A CRASH, AND WOULDINCREASE THE LIKELIHOOD OF INJURY TO THE SEAT OCCUPANT.
Item Affected: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
Date Announced: 10/13/1983
Description of Recall: THE RIGHT FRONT CROSSOVER PIPE, WHICH CARRIES BRAKE HYDRAULIC FLUID, MAY BREAK AND LEAK FLUID. THIS OCCURS WHEN THE RIGHT FRONT FENDER SKIRT CONTACTS THE PIPE AND VIBRATION CAUSES THE PIPE TO WEAR THROUGH.
Conequence:
Action Need To Fix It: IF THE POSITION AND CLEARANCE OF THE BRAKE PIPE ARE INCORRECT, THE FENDER SKIRT WILL BE ADJUSTED AND A REPLACEMENT PIPE WILL BE INSTALLED.
Notes: VEHICLE DESCRIPTION: LIGHT TRUCKS, FOUR WHEEL DRIVE.SYSTEM: SERVICE BRAKES; FRONT BRAKE HYDRAULIC CROSSOVER PIPE.CONSEQUENCES OF DEFECT: FLUID LEAKAGE WILL RESULT IN THE LOSS OF FRONT BRAKING,AND AN INCREASE IN STOPPING DISTANCE. AN ACCIDENT MAY RESULT, PARTICULARLY INSITUATIONS REQUIRING MINIMUM STOPPING DISTANCE.NOTE: AN INCREASE IN BRAKE PEDAL TRAVEL AND ILLUMINATION OF THE BRAKE WARNINGLIGHT MAY INDICATE THE PROBLEM EXISTS.
Item Affected: EQUIPMENT
Date Announced: 10/24/2007
Description of Recall: CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Conequence: THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Action Need To Fix It: HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes: CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Item Affected: SEATS:FRONT ASSEMBLY:RECLINER
Date Announced: 02/06/1984
Description of Recall: SOME VEHICLES HAVE BUCKET SEAT BACK LOCKS THAT DO NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD 207, ANCHORAGE OF SEATS. IN EVENT OF A CRASH, THE SEAT BACK LOCK MAY NOT FUNCTION.
Conequence:
Action Need To Fix It: INSPECTION OF SEAT BACK LOCKS WILL BE PERFORMED. LOCKS THAT HAVE BENT, BROKEN OR MISSING HOOKS WILL BE REPLACED.
Notes: VEHICLE DESCRIPTION: TWO DOOR PASSENGER VEHICLES AND LIGHT TRUCKS EQUIPPED WITHAR9 OR AV5 BUCKET SEATS.SYSTEM: INTERIOR SYSTEMS, SEAT BACK LOCKS.CONSEQUENCES OF DEFECT: THE SEAT MAY FOLD FORWARD IN A CRASH, AND WOULDINCREASE THE LIKELIHOOD OF INJURY TO THE SEAT OCCUPANT.
Item Affected: VEHICLE SPEED CONTROL
Date Announced: 06/16/1989
Description of Recall: A SMALL NYLON BUSHING IN THE CRUISE CONTROL SERVO BAIL MAY SLIP OUT OF PLACE, CAUSING INTERMITTENT AND UNEXPECTED INCREASES IN ENGINE SPEED OR DIESELING (ENGINE RUN ON WITH IGNITION OFF).
Conequence: SERVO ROD ASSEMBLY COULD CATCH ON ENGINE COMPONENTS ANDRESULT IN A STUCK THROTTLE WITH POTENTIAL FOR A VEHICLE CRASH.
Action Need To Fix It: INSTALL A NEW BUSHING IN CRUISE CONTROL SERVO BAIL.
Notes: SYSTEM: CRUISE CONTROL.VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH CRUISE CONTROL ANDCERTAIN GASOLINE AND DIESEL ENGINES.
Item Affected: EXTERIOR LIGHTING
Date Announced: 03/23/2006
Description of Recall: CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Conequence: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Action Need To Fix It: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes: THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES. FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS." CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Item Affected: EXTERIOR LIGHTING
Date Announced: 05/24/2006
Description of Recall: CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Conequence: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Action Need To Fix It: CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS. FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS." CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Item Affected: EXTERIOR LIGHTING:HEADLIGHTS
Date Announced: 08/11/2008
Description of Recall: K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Conequence: WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Action Need To Fix It: K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY HONDA, FORD, OR CHRYSLER LLC. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Item Affected: SEATS:FRONT ASSEMBLY:RECLINER
Date Announced: 02/06/1984
Description of Recall: SOME VEHICLES HAVE BUCKET SEAT BACK LOCKS THAT DO NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD 207, ANCHORAGE OF SEATS. IN EVENT OF A CRASH, THE SEAT BACK LOCK MAY NOT FUNCTION.
Conequence:
Action Need To Fix It: INSPECTION OF SEAT BACK LOCKS WILL BE PERFORMED. LOCKS THAT HAVE BENT, BROKEN OR MISSING HOOKS WILL BE REPLACED.
Notes: VEHICLE DESCRIPTION: TWO DOOR PASSENGER VEHICLES AND LIGHT TRUCKS EQUIPPED WITHAR9 OR AV5 BUCKET SEATS.SYSTEM: INTERIOR SYSTEMS, SEAT BACK LOCKS.CONSEQUENCES OF DEFECT: THE SEAT MAY FOLD FORWARD IN A CRASH, AND WOULDINCREASE THE LIKELIHOOD OF INJURY TO THE SEAT OCCUPANT.
Item Affected: SERVICE BRAKES, AIR:SUPPLY:HOSES, LINES/PIPING, AND FITTINGS
Date Announced: 07/02/1985
Description of Recall: THE FRONT AIR BRAKE HOSE MAY CONTACT THE INNER FENDER ON THE LEFT AND/OR RIGHT SIDES OF SOME TRUCKS. IN SOME INSTANCES, THE BRAKE HOSE MAY RUB THROUGH, RESULTING IN A LOSS OF AIR PRESSURE UPON BRAKE APPLICATION. CONSEQUENCE OF DEFECT: BRAKE HOSE MAY RUB THROUGH CAUSING AIR PRESSURE LOSS WHEN BRAKES ARE APPLIED AND REDUCED BRAKING ABILITY. A REDUCTION OF BRAKING ABILITY AT A TIME WHEN MINIMUM STOPPING DISTANCE IS REQUIRED COULD RESULT IN A VEHICLE CRASH WITHOUT PRIOR WARNING.
Conequence:
Action Need To Fix It: INSTALL NEW BRAKE CHAMBER SUPPORT BRACKETS, BRAKE LINE ELBOWS, AND AIR BRAKE HOSES, AS NECESSARY.
Notes: VEHICLE DESCRIPTION: MEDIUM DUTY TRUCKS EQUIPPED WITH TILT HOODS, 7000# FRONT AXLE AND AIR BRAKES. SYSTEM: FRONT BRAKE HOSE.
Item Affected: FUEL SYSTEM, GASOLINE
Date Announced: 05/19/2006
Description of Recall: CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Conequence: THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Action Need To Fix It: HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Item Affected: EQUIPMENT:AIR CONDITIONER
Date Announced: 08/20/1984
Description of Recall: PLASTIC PLUG LOCATED ON TOP OF THE FRONT AIR CONDITIONER WAS NOT REMOVED DURING ASSEMBLY. THIS DEFECT DISRUPTS NORMAL OPERATION OF EVAPORATOR BLOWER HOUSING.
Conequence:
Action Need To Fix It: REAR A/C SYSTEM BLOWER WILL BE INSPECTED FOR DAMAGE SUCH AS MELTING OR BURNING. IF NO DAMAGE IS DETECTED, THE RESISTOR WILL BE REPLACED AND ANY REMAINING PIECES WILL BE REMOVED. IF DAMAGE IS DETECTED, THE RESISTOR AND THE A/C EVAPORATOR INLET CASE WILL BE REPLACED.
Notes: VEHICLE DESCRIPTION: TRUCKS (VANS) EQUIPPED WITH FRONT AIR CONDITIONERS.SYSTEM: VENTILATION; AIR CONDITIONER.CONSEQUENCES OF DEFECT: ENGINE FIRE COULD START WITHOUT WARNING AND CAUSE FIREDAMAGE TO VEHICLE AND INJURY TO PASSENGERS.
Item Affected: EQUIPMENT
Date Announced: 10/24/2007
Description of Recall: CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Conequence: THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Action Need To Fix It: HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes: CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Item Affected: EQUIPMENT
Date Announced: 10/24/2007
Description of Recall: CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Conequence: THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Action Need To Fix It: HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes: CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Item Affected: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
Date Announced: 08/17/1984
Description of Recall: REAR BRAKE HOSES WERE NOT PROPERLY MANUFACTURED AND DO NOT CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 106, "BRAKE HOSES". HOSES COULD COME LOOSE FROM THE END FITTINGS WHEN SUBJECTED TO A PULLING FORCE.
Conequence:
Action Need To Fix It: A NEW HOSE WILL BE INSTALLED IF NECESSARY. IN ADDITION, BRAKES WILL BE SERVICED.
Notes: VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: SERVICE BRAKES; REAR BRAKE HOSE.CONSEQUENCES OF DEFECT: SEPARATION OF THE HOSE FROM ITS METAL END FITTING WOULDRESULT IN LOSS OF BRAKE FLUID AND LOSS OF SOME BRAKE ACTION. AN ACCIDENT COULDRESULT UNDER CIRCUMSTANCES REQUIRING MINIMUM STOPPING DISTANCE.
Item Affected: SEATS:FRONT ASSEMBLY:RECLINER
Date Announced: 02/06/1984
Description of Recall: SOME VEHICLES HAVE BUCKET SEAT BACK LOCKS THAT DO NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD 207, ANCHORAGE OF SEATS. IN EVENT OF A CRASH, THE SEAT BACK LOCK MAY NOT FUNCTION.
Conequence:
Action Need To Fix It: INSPECTION OF SEAT BACK LOCKS WILL BE PERFORMED. LOCKS THAT HAVE BENT, BROKEN OR MISSING HOOKS WILL BE REPLACED.
Notes: VEHICLE DESCRIPTION: TWO DOOR PASSENGER VEHICLES AND LIGHT TRUCKS EQUIPPED WITHAR9 OR AV5 BUCKET SEATS.SYSTEM: INTERIOR SYSTEMS, SEAT BACK LOCKS.CONSEQUENCES OF DEFECT: THE SEAT MAY FOLD FORWARD IN A CRASH, AND WOULDINCREASE THE LIKELIHOOD OF INJURY TO THE SEAT OCCUPANT.
Item Affected: SEAT BELTS:FRONT:WEBBING
Date Announced: 12/20/1985
Description of Recall: DISLOCATION OF A SPRING COVER WILL NOT ALLOW THE SHOULDER BELT TO RETRACT AFTER BEING EXTENDED. CONSEQUENCE OF DEFECT: ALTHOUGH INERTIAL FEATURE THAT LOCKS THE LAP BELT AND SHOULDER BELT IN THE EVENT OF AN ACCIDENT ARE NOT AFFECTED, IF SLACK IS MORE THAN RECOMMENDED IN OWNERS MANUAL, INJURIES TO UPPER BODY AND HEAD WOULD BE INCREASED IN AN ACCIDENT.
Conequence:
Action Need To Fix It: INSTALL RETAINING SPRINGS ON SPRING COVER OF FRONT SHOULDER BELT RETRACTOR AND, WHEN REQUIRED, RETRACTORS WILL BE REPLACED.
Notes: SYSTEM: SHOULDER SEAT BELT RETRACTOR. VEHICLE DESCRIPTION: PASSENGER CARS.
Item Affected: PARKING BRAKE:CONVENTIONAL
Date Announced: 04/11/1991
Description of Recall: PARKING BRAKE ADJUSTER FAILS TO OPERATE AND DO NOT WORK AFTER BRAKE PAD WEAR.
Conequence: PARKING BRAKES WILL NOT COMPLETELY HOLD A PARKED VEHICLEWHEN PARKED ON A SLOPE, CAUSING UNINTENDED VEHICLE ROLLAWAY WHICH COULD RESULTIN A VEHICLE ACCIDENT.
Action Need To Fix It: REPLACE NONFUNCTIONING PARKING BRAKE ADJUSTERS.
Notes: SYSTEM: PARKING BRAKE.VEHICLE DESCRIPTION: PASSENGER CARS; FIREBIRDS AND CAMAROS WITH MANUALTRANSMISSIONS AND REAR DISK BRAKES AND FIEROS WITH MANUAL TRANSMISSIONS.
Item Affected: SEAT BELTS:FRONT:BUCKLE ASSEMBLY
Date Announced: 05/14/1990
Description of Recall: PLASTIC COMPONENTS OF SEAT BELT BUCKLE ASSEMBLIES DO NOT CONTAIN AN ULTRA VIOLET STABILIZER, AND EXPOSURE TO DIRECT SUNLIGHT AND ELEVATED INTERIOR TEMPERATURES COULD WEAKEN THE PLASTIC COMPONENTS.
Conequence: THIS COULD RESULT IN BREAKAGE OF PLASTIC COMPONENTS WHICHCOULD PREVENT BUCKLE FROM LATCHING AND PROTECTING OCCUPANT IN A SUDDEN STOP ORACCIDENT.
Action Need To Fix It: REPLACE OR REPAIR SEAT BELT BUCKLE.
Notes: SYSTEM: SEAT BELT BUCKLE.VEHICLE DESCRIPTION: PASSENGER CARS.
Item Affected: EQUIPMENT:AIR CONDITIONER
Date Announced: 08/20/1984
Description of Recall: PLASTIC PLUG LOCATED ON TOP OF THE FRONT AIR CONDITIONER WAS NOT REMOVED DURING ASSEMBLY. THIS DEFECT DISRUPTS NORMAL OPERATION OF EVAPORATOR BLOWER HOUSING.
Conequence:
Action Need To Fix It: REAR A/C SYSTEM BLOWER WILL BE INSPECTED FOR DAMAGE SUCH AS MELTING OR BURNING. IF NO DAMAGE IS DETECTED, THE RESISTOR WILL BE REPLACED AND ANY REMAINING PIECES WILL BE REMOVED. IF DAMAGE IS DETECTED, THE RESISTOR AND THE A/C EVAPORATOR INLET CASE WILL BE REPLACED.
Notes: VEHICLE DESCRIPTION: TRUCKS (VANS) EQUIPPED WITH FRONT AIR CONDITIONERS.SYSTEM: VENTILATION; AIR CONDITIONER.CONSEQUENCES OF DEFECT: ENGINE FIRE COULD START WITHOUT WARNING AND CAUSE FIREDAMAGE TO VEHICLE AND INJURY TO PASSENGERS.
Item Affected: EQUIPMENT
Date Announced: 10/24/2007
Description of Recall: CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Conequence: THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Action Need To Fix It: HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes: CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
