JAYCO GRANITE RIDGE Recalls
Item Affected: POWER TRAIN:DRIVELINE:DRIVESHAFT
Date Announced: 01/13/2006
Description of Recall: CERTAIN MOTOR HOMES MAY HAVE U-JOINT RETAINING CLIPS MISSING OR NOT INSTALLED PROPERLY. IF THE RETAINING CLIPS ARE NOT INSTALLED PROPERLY, THE U-JOINT MAY BECOME DISLODGED FROM THE YOKE AND THE DRIVE SHAFT WILL BECOME DISCONNECTED FROM THE DRIVE TRAIN.
Conequence: THIS CONDITION, IF NOT ADDRESSED, COULD RESULT IN A CRASH, INJURY OR DEATH.
Action Need To Fix It: DEALERS HAVE COMPLETED THE REPAIRS TO 100 PERCENT OF THE UNITS AT THE FACTORY AND AT DEALERSHIPS. NO FURTHER ACTION IS NECESSARY ON THIS RECALL.
Notes: CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
Item Affected: VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR
Date Announced: 03/30/2006
Description of Recall: ON CERTAIN MOTOR HOMES, THE WINDSHIELD WIPER MOTOR MAY HAVE BEEN PRODUCED WITHOUT GREASE BEING APPLIED TO THE OUTPUT SHAFT GEAR.
Conequence: AFTER A PERIOD OF CONTINUOUS USE ON THE HIGH SPEED SETTING, LACK OF GREASE ON THE OUTPUT SHAFT GEAR MAY CAUSE THE GEAR TO DISTORT OR FRACTURE DURING OPERATION RESULTING IN A LOSS OF WIPER FUNCTION. INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.
Action Need To Fix It: FORD IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL INSPECT THE WIPER MOTOR FOR THE PRESENCE OF GREASE AND GREASE THE WIPER MOTOR GEARS IF NECESSARY. ALL VEHICLES HAVE BEEN REMEDIED.
Notes: CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
Item Affected: ELECTRICAL SYSTEM:BATTERY:CABLES
Date Announced: 01/12/2005
Description of Recall: ON CERTAIN MOTOR HOMES THE BATTERY CABLE MAY HAVE BEEN ROUTED TOO CLOSE TO THE EXHAUST MANIFOLD.
Conequence: THIS COULD CAUSE THE CABLE TO MELT, CREATING AN ELECTRICAL SHORT, WHICH COULD RESULT IN A FIRE.
Action Need To Fix It: DEALERS WILL INSPECT AND REROUTE AND/OR REPLACE THE BATTERY CABLE FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 28, 2005. OWNERS MAY CONTACT JAYCO AT 574-825-5861.
Notes: CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
Item Affected: TRAILER HITCHES
Date Announced: 12/16/2005
Description of Recall: ON CERTAIN MOTOR HOMES, THE HITCH RECEIVER MAY HAVE MISSING REINFORCING PLATES. WHEN A LOAD IS APPLIED TO THE HITCH, IT MAY BECOME PARTIALLY DETACHED FROM THE FRAME IF THESE PLATES ARE MISSING.
Conequence: THIS CONDITION, IF NOT ADDRESSED, COULD RESULT IN A CRASH, PERSONAL INJURY OR DEATH.
Action Need To Fix It: DEALERS WILL INSPECT AND REPLACE THE REINFORCING PLATES WITH NEW HARDWARE. THE RECALL BEGAN ON JANUARY 10, 2006. OWNERS MAY CONTACT JAYCO AT 1-800-283-8267.
Notes: CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
Item Affected: EQUIPMENT:OTHER:LABELS
Date Announced: 04/10/2006
Description of Recall: CERTAIN MOTOR HOMES BUILT ON FORD E-450 CHASSIS, AND EQUIPPED WITH LT225/75R16E TIRES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, 'TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS.' THE TIRE PRESSURE IS INCORRECTLY LISTED ON THE LABEL FOR THE REAR TIRES.
Conequence: AT THE INCORRECTLY STATED PRESSURE, THE REAR TIRES ARE UNABLE TO SUPPORT THE GROSS AXLE WEIGHT RATING (GAWR) FOR THE REAR AXLE.
Action Need To Fix It: OWNERS WILL BE MAILED SUPPLEMENTARY TIRE LABELS CONTAINING THE CORRECT REAR TIRE INFLATION INFORMATION. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR JAYCO AT 1-800-283-8267 .
Notes: CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
Item Affected: ENGINE AND ENGINE COOLING
Date Announced: 03/28/2006
Description of Recall: ON CERTAIN MOTOR HOMES BUILT ON FORD E-SERIES CHASSIS, THE AIR FILTER ELEMENT MATERIAL PROCESS RESULTED IN AN AIR FILTER PAPER ELEMENT THAT CAN SMOLDER OR BURN. THIS CHANGE IN FILTER PAPER COMPOSITION, COMBINED WITH THE CONFIGURATION OF THE AIR INDUCTION SYSTEM, MAY ALLOW HOT CARBON PARTICLES TO CONTACT THE AIR FILTER ELEMENT DURING CERTAIN DRIVING CONDITIONS THAT CREATE HOT PARTICLES.
Conequence: THESE HOT PARTICLES MAY IGNITE THE AIR FILTER ELEMENT WITH THE POTENTIAL FOR AIR INDUCTION SYSTEM DAMAGE OR UNDERHOOD FIRE.
Action Need To Fix It: FORD MOTOR COMPANY IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL INSPECT AND REPLACE THE AIR FILTER ELEMENT. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673 OR JAYCO AT 1-800-283-8267.
Notes: CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
Item Affected: ELECTRICAL SYSTEM:WIRING
Date Announced: 03/31/2006
Description of Recall: CERTAIN MOTOR HOMES BUILT ON FORD CHASSIS MAY EXPERIENCE STALLING WITHOUT WARNING WHILE DRIVING AND MAY OR MAY NOT RESTART.
Conequence: SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.
Action Need To Fix It: FORD MOTOR COMPANY IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL UPGRADE THE FUEL INJECTION CONTROL MODULE (FICM) WIRE HARNESS OR REPLACED, AND/OR HAVE A NEW INJECTION CONTROL PRESSURE (ICP)) SENSOR CONNECTOR INSTALLED FREE OF CHARGE. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR JAYCO AT 1-800-283-8267.
Notes: CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
